CCZVZ - PLASTIC SEAL AEROSOL
- MSDS: CCZVZ
- Manufacturer: FIBRE GLASS EVERCOAT CO
- Product Name: PLASTIC SEAL AEROSOL
- National Stock Number: 6830-00F052013
Product Identification
Product ID:PLASTIC SEAL AEROSOL
MSDS Date:06/09/1989
FSC:6830
NIIN:00F052013
MSDS Number: CCZVZ
Responsible Party
CINCINNATI, OH 45242-5000
US
Emergency Phone: 800-729-7600
Info Phone: 513-489-7600/800-729-7600
Cage: 18731
Contractor
Telephone: 513-489-7600
Cage: 18731
Ingredients
TOLUENE (IARC CARC- GROUP 3) *96-3*
CAS: 108-88-3
RTECS: XS5250000
Fraction By Weight: <95%
OSHA PEL 100 PPM
ACGIH TLV: 100 PPM
EPA Report Quantity: 1000 LBS
DOT Report Quantity: 1000 LBS
XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *96-3*
CAS: 1330-20-7
RTECS: ZE2100000
Fraction By Weight: <5%
OSHA PEL 100 PPM
ACGIH TLV: 100 PPM, SKIN
EPA Report Quantity: 1000 LBS
DOT Report Quantity: 1000 LBS
PROPANE (DIMETHYLMETHANE) *96-3*
CAS: 74-98-6
RTECS: TX2275000
Fraction By Weight: <20%
OSHA PEL 1000 PPM
ACGIH TLV: SIMPLE ASPHYXIANT
Hazards
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: IRRITATION. SKIN: IRRITATION,
DERMATITIS. INHALATION: ASPHYXIATION. OVEREXPOSURE CAN CAUSE
CHEMICAL PNEUMONITIS WHICH CAN BE FATAL & HAS BEEN SUGGESTED TO
CAUSE LIVER ABNORMALITIES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIZZINESS, WEAKNESS, HEADACHE,
UNCONSCIOUSNESS, NAUSEA, VOMITING, REDNESS, TEARING, BLURRED
VISION.
First Aid
First Aid:EYES: FLUSH W/WATER. SKIN: WASH THOROUGHLY W/SOAP & WATER.
INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED.
INGESTION: DON'T INDUCE VOMITING. KEEP WARM & QUIET. OBTAIN MEDICAL
ATTENTION IN ALL CASES.
Fire Fighting
Flash Point Method:TCC
Flash Point:-40F
Lower Limits:1.2
Upper Limits:12
Extinguishing Media:FOAM, CO2/DRY CHEMICAL.
Fire Fighting Procedures:USE SCBA W/FULL FACE SHIELD.
Unusual Fire/Explosion Hazard:VAPOR ARE >AIR & MAY TRAVEL ALONG THE
GROUND TO IGNITION SOURCES. AEROSOLS MAY RUPTURE WHEN HEATED.
Accidental Release
Spill Release Procedures:REMOVE IGNITION SOURCES. ABSORB W/PAPER,
VERMICULITE/FLOOR ABSORBANT. SMALL: WILL EVAPORATE.
Handling
Handling and Storage Precautions:STORE IN ORIGINAL CONTAINER, AWAY FROM
HEAT, SUNLIGHT & OTHER IGNITION SOURCES. HEATED AEROSOL CANS MAY
BURST.
Exposure Controls
Respiratory Protection:REQUIRED IF TLVS ARE EXCEEDED.
Ventilation:MECHANICAL (GENERAL) IF NEEDED TO MAINTAIN EXPOSURE LEVELS
BELOW TLVS.
Protective Gloves:SOLVENT RESISTANT
Eye Protection:SPLASH GOGGLES
Other Protective Equipment:PREFERRED TO PREVENT CONTACT/EXPOSURE.
Work Hygienic Practices:WASH THOROUGHLY W/SOAP & WATER IF SKIN CONTACT
IS MADE.
Supplemental Safety and Health
Chemical Properties
Boiling Pt:B.P. Text:-45F
Vapor Pres:35
Vapor Density:>1
Spec Gravity:0.8
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR, THIN LIQUID W/SHARP AROMATIC ODOR.
Percent Volatiles by Volume:90
Stability
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS, OPEN FLAMES &
OTHER IGNITION SOURCES, SUNLIGHT.
Hazardous Decomposition Products:CO, CO2.
Disposal
Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. CAN BE INCINERATED.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.